CBPBT - MARINE ANTIFREEZE -50 DEGREE
- MSDS: CBPBT
- Manufacturer: NOBLE CO
- Product Name: MARINE ANTIFREEZE -50 DEGREE
- National Stock Number: 6850-00N071561
Product Identification
Product ID:MARINE ANTIFREEZE -50 DEGREE
MSDS Date:05/01/1995
FSC:6850
NIIN:00N071561
MSDS Number: CBPBT
Responsible Party
GRAND HAVEN, MI 49417-1065
US
Emergency Phone: 616-842-7844
Info Phone: 616-842-7844
Cage: JO357
Contractor
Telephone: 616-842-7844
Cage: 54756
Ingredients
1,2-PROPANEDIOL; (PROPYLENE GLYCOL)
CAS: 57-55-6
RTECS: TY2000000
OSHA PEL N/K
ACGIH TLV: N/K
POTASSIUM PHOSPHATE; DIBASIC
CAS: 7758-11-4
OSHA PEL N/K
ACGIH TLV: N/K
WATER
CAS: 7732-18-5
RTECS: ZC0110000
OSHA PEL N/K
ACGIH TLV: N/K
COOLING. AVOID FROTHING/STEAM EXPLOSION. BURNING LIQ
RTECS: 9999999ZZ
PRACTICAL TO EXTINGUISH FIRE BY WATER DILUTION. NOTE
RTECS: 9999999ZZ
TRAVEL LONG DISTANCES ALONG GROUND BEFORE
RTECS: 9999999ZZ
MAY BE COMBUSTIBLE AT TEMPERATURES BELOW NORMAL FLASH
RTECS: 9999999ZZ
ASSURE EMISSIONS COMPLY W/APPLIC REGS.
RTECS: 9999999ZZ
POISONING PLANT BIOMASS. ASSURE EFFLUENT COMPLIES
RTECS: 9999999ZZ
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE MINOR EYE
IRRITATION. CHRONIC:NONE LISTED BY MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
First Aid
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) . SKIN:FLUSH W/COPIOUS
AMOUNTS OF WATER. CALL MD . EYES:IMMEDIATELY RINSE W/CLEAN WATER
FOR AT LEAST 15 MINUTES. RETRACT EYELIDS OFTEN. OBTAIN EMERGENCY
MEDICAL ATTENTION IF PAIN, BLINKING, TEARS, OR REDNESS PERSIST.
Fire Fighting
Flash Point Method:TCC
Flash Point:211F,99C
Lower Limits:2.0%
Upper Limits:13.0%
Extinguishing Media:DRY CHEMICAL, WATERSPRAY, WATER FOG, CO*2, OR
ALCOHOL TYPE FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP . DO
NOT ENTER FIRE AREA W/OUT PROPER PROT. SEE SECTION - DECOMP PRODS
POSS. FIGHT FIRE FROM DISTANCE/ (SUPDAT)
Unusual Fire/Explosion Hazard:HEAT FROM FIRE CAN GENERATE FLAMM VAP.
WHEN MIXED W/AIR & EXPOS TO IGNIT SOURCE, VAPS CAN BURN IN
OPEN/EXPLODE IF CONFINED. VAPS MAY BE HVR/AIR. MAY (ING 6)
Accidental Release
Spill Release Procedures:SLIPPERY-SPREAD GRANULAR COVER.
IMPOUND/RECOVER LG LAND SPILL; SOAK UP SM SPILL ON WATER, MATL SOL.
CONTAIN/MINIMIZE DISPERSION/COLLECT. HIGHLY BIODEGRADABLE-CAN
STIMULATE ALGAE GROWTH WHEN NOT PROPER LY INHIBITED. RPT PER
REGULATORY REQUIREMENTS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:STORE IN TIGHTLY CLSD CNTNRS. STORE
AWAY FROM HEAT/MOISTURE/STRONG OXIDIZING AGENTS. MATL CAN ATTACK
SOME FORMS OF PLASTICS.
Other Precautions:WHEN NORM HNDLG REQS HEATING, DO NOT HEAT >50F BELOW
FLASH POINT UNLESS IN CLSD SYS AWAY FROM AIR. HANDLE EMPTY CNTNRS
WITH CARE/RESIDUE CAN BURN IF HEATED. DRAIN ANY NEC RESIDUE TO
SEWER CAREFULLY TO PVNT UPSET TO SEWAGE TREATMENT.
Exposure Controls
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION EQUIPMENT IS
RECOMMENDED UNDER ANTICIPATED CONDITIONS OF NORMAL USE WITH
ADEQUATE VENTILATION. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN (FP N).
Ventilation:AT ELEVATED TEMPERATURES, SPECIAL VENTILATION MAY BE
REQUIRED.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
SPEC GRAV:1.03 @ 20C/4C (68F/32.9F). VAP DENS:2.6 (AIR=1.0 @ 60-90F).
FL PT:211F,99C FOR PURE PROPYLENE GLYCOL (PG). THE BL-50 MIX WILL
BE CONSIDERABLY HIGHER. FIRE FIGHT PROC:PROTECTED LOCATION. HEAT
MAY BUILD PRESS/RUPTURE CLSD CNTNRS. SPREADING FIRE, INCREASING
RISK OF BURNS/INJURIES. USE WATER APRAY/FOG FOR (ING 4)
Chemical Properties
Boiling Pt:B.P. Text:214F,101C
Vapor Pres:19 @ 70F
Vapor Density:SUPDAT
Spec Gravity:SUPDAT
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:COMPLETE
Appearance and Odor:FD&C RED #40 DYE, SLIGHTLY VISCOUS, RELATIVELY
ODORLESS.
Stability
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUST MAY PRDCE CARBON
MONOXIDE & OTHER HARMFUL GASES/VAPORS, INCLUDING OXIDES OF
PHOSPHOROUS & POTASSIUM.
Disposal
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS .
CONTAMD PROD/SOIL/WATER SHOULD BE CONSIDERED DANGEROUS DUE TO
POTNTL FOR ENVIR HARM. LANDFILL SOLIDS AT PERMITTED SITES. USE
REGISTERED TRANSPORTERS. B URN CONCENTRATED LIQS. AVOID
FLAMEOUTS.(ING 8)
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.